XCLUSIVE MOTOR SERVICES
ADDRESS – 72-75 MOSELEY STREET, DIGBETH, BIRMINGHAM, B12 0RT
/
CALL – 0121 6666 121
| Engine | Full Service | Major Service |
|---|---|---|
| Drain Engine Oil and Refill (at additional cost for long life oil or low ash oil) | ||
| Replace Oil Filter | ||
| Check for Excessive Oil Leaks | ||
| Check for timing belt (cambelt) report if replacement due according to mileage of vehicle | ||
| Check Radiator Condition | ||
| Check Coolant Cap Seals | ||
| Check coolant hoses for leaks and condition and security | ||
| Replace Air Filter | ||
| Change Spark Plugs (Premium plugs at additional) | ||
| Check coolant and top up when required | ||
| Replace coolant | ||
| Check condition and security of under tray | ||
| Fuel | Full | Major |
| Check fuel cap seal condition | ||
| Check visual conditions of fuel lines | ||
| Replace fuel filter if required | ||
| Drive System | Full | Major |
| Check for correct clutch operation | ||
| Check for correct gearbox operation | ||
| Check and top up clutch fluid where applicable | ||
| Check drive shaft gaitors and report leaks | ||
| Grease prop/shaft if applicable | ||
| Check and top up axle and/or transaxle oil if applicable | ||
| Electrical | Full | Major |
| Check operation of exterior lights | ||
| Check horn | ||
| Check diesel heater plug indicator operation where fitted | ||
| Check battery security and lubricate terminals | ||
| Check battery condition | ||
| Check Dashboard warning lights | ||
| Visual inspection of HT leads | ||
| Test effectiveness of starter motor | ||
| Steering and Suspension | Full | Major |
| Check and top up power steering reservoir where applicable | ||
| Check steering and suspension components for wear and corrosion | ||
| Check steering rack gaitors condition | ||
| Check wheel bearings for excessive play | ||
| Carry out shock absorber bounce test | ||
| Grease steering and suspension where applicable | ||
| Exhaust | Full | Major |
| Inspect exhaust system (including catalyst if fitted) for leaks, noise and security | ||
| Visual check for exhaust smoke | ||
| Brakes | Full | Major |
| Check brake pads for wear or damage | ||
| Check brake calipers for leaks and security | ||
| Check service brake shoes for wear or damage | ||
| Inspect operation of wheel cylinders and report any leaks | ||
| Visually check brake hydraulic system, pipes and hoses for any leaks, chafing and corrosion | ||
| Check security of handbrake linkages and travel | ||
| Check brake discs and drums for wear, cracks, corrosion and scoring (excluding internal drums) | ||
| Check brake fluid level and top up if required | ||
| Replace brake fluid | ||
| Check brake servo operation | ||
| Carry out brake fluid test and record readings | ||
| Tyres and Wheels | Full | Major |
| Remove road tyres | ||
| Check tyre has been fitted correctly | ||
| Check tyre condition and tread depth | ||
| Check and adjust tyre pressures | ||
| Set wheel nut torque to manufacturer’s settings | ||
| Vision | Full | Major |
| Check windscreen wiper condition and operation | ||
| Check rear wiper condition and operation | ||
| Check windscreen washer operations, top up if required | ||
| Check windscreen for chips and cracks | ||
| Check mirror condition (interior and exterior) | ||
| Check number plate condition | ||
| Internal | Full | Major |
| Replace Cabin Filter | ||
| Check seat belts front and rear | ||
| Check operation of all external door locks | ||
| Lubricate accessible door hinges (with white grease) | ||
| General | Full | Major |
| Reset vehicle service light (where applicable) | ||
| Conduct road test | ||
| Lubricate bonnet catch | ||
| Stamp service book or register online for digital service book | ||
| Points Checked | 60 | 69 |
